Class B60-B80 cement concretes using crushed gravel from the Kama field

Cover Page

Cite item

Full Text

Open Access Open Access
Restricted Access Access granted
Restricted Access Subscription or Fee Access

Abstract

The results of a study of the quality of crushed stone from gravel of fr. 5–20 mm and screening of crushing of fr. 0–5 mm of the Kama field were presented and an analysis of their compliance with the requirements of regulatory documents was carried out. The characteristics of the crushing products were determined: grain composition, content of crushed grains; amount of lamellar (flaky) and needle-like shape, presence of dust-like and clay particles, crushed stone crushability during compression in a cylinder, screening fineness modulus and content of reaction silica in crushed stone and screening. Compositions of high-strength concretes of class B60–B80 were developed, in which fine quartz sand was used to enrich the crushing screening, carbonate mineral powder of MP-1 grade and microsilica (MK-85) as a filler, and polycarboxylate superplasticizer Polyplast PK as a water-reducing additive. Optimal compositions were obtained with the following cement consumption: for concrete B60 with a compression strength of 78 MPa, cement consumption was 466 kg/m3, for class B70 with a strength of 91 MPa – 483 kg/m3 and for B80 with a strength of 104 MPa – 503 kg/m3. At the same time, concrete mixtures were characterized by a cone settlement of 25–27 cm.

Full Text

Restricted Access

About the authors

K. O. Nesterova

Kazan State University of Architecture and Civil Engineering

Author for correspondence.
Email: nesterova4301@mail.ru

Master Student 

Russian Federation, 1, Zelenaya Street, Kazan, 420043

A. R. Gizzatullin

Kazan State University of Architecture and Civil Engineering

Email: anasrg@yandex.ru

Candidate of Sciences (Engineering) 

Russian Federation, 1, Zelenaya Street, Kazan, 420043

N. N. Morozova

Kazan State University of Architecture and Civil Engineering

Email: ninamor@mail.ru

Candidate of Sciences (Engineering) 

Russian Federation, 1, Zelenaya Street, Kazan, 420043

I. I. Gainutdinov

Kazan State University of Architecture and Civil Engineering

Email: gailfat16@mail.ru

Master Student 

Russian Federation, 1, Zelenaya Street, Kazan, 420043

V. G. Khozin

Kazan State University of Architecture and Civil Engineering

Email: Khozin.Vadim@yandex.ru

Doctor of Sciences (Engineering), Professor 

Russian Federation, 1, Zelenaya Street, Kazan, 420043

References

  1. Mavliev L.F., Vdovin E.A., Konovalov N.V., et al. Development of road construction material based on cement-treated crushed stone-sand mixture of optimal granulometric composition. Izvestiya of the Kazan State University of Architecture and Civil Engineering. 2019. No. 4 (50), pp. 435–443. (In Russian). EDN: RUEQJF
  2. Fomin A.Yu., Askarova R.N., Khozin V.G. High-strength grey crushed stone from carbonate rocks for the construction of foundations in road pavement structures. Izvestiya of the Kazan State University of Architecture and Civil Engineering. 2022. No. 1 (59), pp. 54–63. (In Russian). EDN: VBHJTW. https://doi.org/10.52409/20731523_2022_1_54
  3. Permyakov S.V., Novitskii E.V., Gabdullin T.R. Crushed stone and sand mixture of non-optimal granulometric composition, treated with cement. Avtomobil’nye dorogi i transportnaya infrastruktura. 2023. No. 4 (4), pp. 45–50. (In Russian). EDN: GOXWVK
  4. Itskovich S.M., Chumakov L.D., Bazhenov Yu.M. Tekhnologiya zapolnitelei betona [Concrete aggregate technology] Moscow: Vysshaya shkola. 1991. 272 p.
  5. Poleiko N.L., Leonovich S.N. On the effective use of coarse aggregate in concrete. Stroitel’stvo i rekonstruktsiya. 2014. No. 5 (55), pp. 101–105. (In Russian). EDN: OXOWIX
  6. Vorob’ev V.A., Kolbasin A.M. Automation of preparation of large aggregate for concrete mixtures with prompt correction of its fractional composition. Stroitel’stvo i rekonstruktsiya. 2015. No. 3 (59), pp. 125–129. (In Russian). EDN: TQTURN
  7. Razin S.N., Maklakova S.N., Molodkina O.A., Evseeva T.M. On the methodology of experimental study of concrete tensile strength under plane deformation conditions. Globus: tekhnicheskie nauki. 2019. No. 2 (26), pp. 18–27. (In Russian). EDN: HEXYTO
  8. Vaisberg L.A., Shuloyakov A.D., Orlov S.L., Spiridonov P.A., Dalatkazin A.A. New technologies for the production of high-quality cubic crushed stone of small fractions. Gornaya promyshlennost’. 2010. No. 3 (91), pp. 10–13. (In Russian). EDN: MWBBSP
  9. Artamonov V.A., Vorob’ev V.V., Svitov V.S. Experience in processing crushed screenings. Stroitel’nye Materialy [Construction Materials]. 2003. No. 6, pp. 28–29. (In Russian). EDN: IBEJFH
  10. Kharo O.E., Levkova N.S., Lopatnikov M.I., Gornostaeva T.A. Use of waste from rock processing in the production of non-metallic building materials. Stroitel’nye Materialy [Construction Materials]. 2003. No. 9, pp. 18–19. (In Russian). EDN: IBEKDD
  11. Morozov N.M., Muginov Kh.G., Khozin V.G., Antakov A.B. High-strength sand concretes for monolithic construction. Izvestiya of the Kazan State University of Architecture and Civil Engineering. 2012. No. 2 (20), pp. 183–188. (In Russian). EDN: PASZXD
  12. Mirsayapov I.T., Fattakhova A.I. Technical and economic assessment of the impact of increasing the strength and durability of concrete through the use of high-strength concrete on the consumption of materials in reinforced concrete frames of series 1.020-1/83. Izvestiya of the Kazan State University of Architecture and Civil Engineering. 2017. No. 4 (42), pp. 182–188. (In Russian). EDN: ZTSUKR
  13. Kalashnikov V.I., Tarakanov O.V. On the use of complex additives in new generation concretes. Stroitel’nye Materialy [Construction Materials]. 2017. No. 1–2, pp. 62–67. (In Russian). EDN: XXIHSZ
  14. Belyakov A.Yu., Khokhryakov O.V., Khozin V.G. Functionalized mineral filler – an effective modifier of cement concrete. Izvestiya of the Kazan State University of Architecture and Civil Engineering. 2023. No. 3 (65), pp. 45–56. (In Russian).EDN: FCPOKY. https:// doi.org/10.52409/20731523_2023_3_45
  15. Tarakanov O. V., Belyakova E.A. Expanding the base of mineral and complex additives for concrete using secondary raw materials. Polimery v stroitel’stve: scientific online journal. 2022. No. 1 (10), pp. 62–68. (In Russian). EDN: SRSYEY
  16. Akberova S.M., Gakhramanov S.G., Kurbanova R.A. Self-compacting concrete based on materials from Azerbaijan. Stroitel’nye Materialy [Construction Materials]. 2022. No. 7. pp. 10–16. (In Russian). EDN: LLPEXH. https://doi.org/10.31659/0585-430X-2022-804-7-10-15

Supplementary files

Supplementary Files
Action
1. JATS XML
2. Fig. 1. Fractional composition of crushed gravel

Download (354KB)
3. Fig. 2. Screening type of gravel crushing with fraction of 0–5 mm, ×100 magnification – a and b; particles of gravel crushing screening with fraction of 0–0.008 mm – c

Download (250KB)
4. Fig. 3. Graph of fractional composition of sand from crushed gravel screenings

Download (710KB)
5. Fig. 4. Concrete fracture on crushed gravel

Download (739KB)
6. Fig. 5. Concrete fracture on syenite rubble

Download (724KB)
7. Fig. 6. Graph of change in strength of fine-grained concrete from cement consumption

Download (338KB)

Copyright (c) 2024 ООО РИФ "СТРОЙМАТЕРИАЛЫ"