High-Temperature Thermodynamic Properties of Hafnium and Rare Earth Oxide Ceramics

V. A. Vorozhtcov; Ворожцов В. А.; V. L. Stolyarova; Столярова В. Л.; S. A. Kirillova; Кириллова С. А.; S. I. Lopatin; Лопатин С. И.

doi:10.31857/S0044457X22601055

High-Temperature Thermodynamic Properties of Hafnium and Rare Earth Oxide Ceramics

Authors: Vorozhtcov V.A.¹^,2, Stolyarova V.L.¹, Kirillova S.A.²^,3, Lopatin S.I.¹^,2
Affiliations:
1. St. Petersburg State University
2. Grebenshchikov Institute of Silicate Chemistry, Russian Academy of Sciences
3. St. Petersburg State Electrotechnical University “LETI”
Issue: Vol 68, No 2 (2023)
Pages: 209-220
Section: ФИЗИКО-ХИМИЧЕСКИЙ АНАЛИЗ НЕОРГАНИЧЕСКИХ СИСТЕМ
URL: https://rjsvd.com/0044-457X/article/view/665305
DOI: https://doi.org/10.31857/S0044457X22601055
EDN: https://elibrary.ru/LOJKSH
ID: 665305

Cite item

Full Text

Open Access
Restricted Access

Access granted
Restricted Access

Subscription or Fee Access

Abstract
About the authors
References
Supplementary files
Statistics

Abstract

Previous experimental data on the vaporization and high-temperature thermodynamic properties of hafnium and rare earth oxide ceramics are considered here. The La2O3–Sm2O3 system is for the first time studied at 2323 K using Knudsen effusion mass spectrometry. As a result of this study, the vapor composition over ceramic samples under investigation is identified, and concentration dependences of the partial pressures of vapor species over the system under study and condensed-phase thermodynamic properties are determined, namely, the component activities and the excess Gibbs energy. The enthalpy of formation from oxides and excess entropy of the La2O3–Sm2O3 system at 2323 K are determined using the Wilson polynomial. The Kohler, Redlich–Kister, and Wilson semiempirical methods were used to calculate the thermodynamic properties in the La2O3–Sm2O3–Y2O3–HfO2 and La2O3–Sm2O3–ZrO2–HfO2 quaternary systems at 2330 K using the equilibrium data gained in the relevant binary systems. The results of the calculations were compared to previous semiempirical estimates of the respective quantities for the La2O3–Y2O3–ZrO2–HfO2 and Sm2O3–Y2O3–ZrO2–HfO2 systems taken as examples. Calculations by the Wilson method are shown to provide the best match with the experimentally obtained lanthanoid oxide activities in the La2O3–Sm2O3–Y2O3–HfO2 and La2O3–Sm2O3–ZrO2–HfO2 systems.

Keywords

vaporization, thermodynamic properties, lanthanum oxide, samarium oxide, high-temperature, mass spectrometry

References

Wang J., Li H.P., Stevens R. // J. Mater. Sci. 1992. V. 27. № 20. P. 5397. https://doi.org/10.1007/BF00541601
Clarke D.R., Phillpot S.R. // Mater. Today. 2005. V. 8. № 6. P. 22. https://doi.org/10.1016/S1369-7021(05)70934-2
Andrievskaya E.R. // J. Eur. Ceram. Soc. 2008. V. 28. № 12. P. 2363. https://doi.org/10.1016/j.jeurceramsoc.2008.01.009
Pan W., Phillpot S.R., Wan C. et al. // MRS Bull. 2012. V. 37. № 10. P. 917. https://doi.org/10.1557/mrs.2012.234
Darolia R. // Int. Mater. Rev. 2013. V. 58. № 6. P. 315. https://doi.org/10.1179/1743280413Y.0000000019
Каблов Е.Н. Литые лопатки газотурбинных двигателей: сплавы, технологии, покрытия. М.: Наука, 2006. 632 с.
Петрушин Н.В., Оспенникова О.Г., Светлов И.Л. // Авиац. материалы и технологии. 2017. Т. 49. С. 72.
Cao X.Q., Vassen R., Stoever D. // J. Eur. Ceram. Soc. 2004. V. 24. № 1. P. 1. https://doi.org/10.1016/S0955-2219(03)00129-8
Чубаров Д.A., Матвеев П.В. // Авиац. материалы и технологии. 2013. Т. 29. № 4. С. 43. https://www.elibrary.ru/item.asp?id=20421193
Vassen R., Jarligo M.O., Steinke T. et al. // Surf. Coat. Technol. 2010. V. 205. № 4. P. 938. https://doi.org/10.1016/j.surfcoat.2010.08.151
Казенас Е.К. Термодинамика испарения двойных оксидов. М.: Наука, 2004. 551 с. https://elibrary.ru/item.asp?id=19468800
Lukas H.L., Fries S.G., Sundman B. Computational thermodynamics: The Calphad method. Cambridge: Cambridge University Press, 2007. 313 p. https://doi.org/10.1017/CBO9780511804137
Schneider S.J., Roth R.S. // J. Res. Natl. Bur. Stand. A. Phys. Chem. 1960. V. 64A. № 4. P. 317. https://doi.org/10.6028/JRES.064A.031
Coutures J., Rouanet A., Verges R., Foex M. // J. Solid State Chem. 1976. V. 17. № 1–2. P. 171. https://doi.org/10.1016/0022-4596(76)90218-8
Корнієнко О.А. // Укр. хім. журн. 2018. Т. 84. № 3. С. 28.
Zinkevich M. // Prog. Mater. Sci. 2007. V. 52. № 4. P. 597. https://doi.org/10.1016/J.PMATSCI.2006.09.002
Казенас Е.К., Цветков Ю.В. Термодинамика испарения оксидов. М.: Изд-во ЛКИ, 2008. 480 с. https://elibrary.ru/item.asp?id=19470483
Гурвич Л.В., Вейц И.В., Медведев В.А. и др. Термодинамические свойства индивидуальных веществ. Справочное издание / Отв. ред. Глушко В.П. М.: Наука, 1982. Т. IV. Кн. 2. 560 с.
Shugurov S.M., Kurapova O.Y., Lopatin S.I. et al. // Rapid Commun. Mass Spectrom. 2017. V. 31. № 23. P. 2021. https://doi.org/10.1002/rcm.7997
Ackermann R.J., Rauh E.G. // J. Chem. Thermodyn. 1971. V. 3. № 4. P. 445. https://doi.org/10.1016/S0021-9614(71)80027-7
Walsh P.N., Goldstein H.W., White D. // J. Am. Ceram. Soc. 1960. V. 43. № 5. P. 229. https://doi.org/10.1111/J.1151-2916.1960.TB14589.X
Goldstein H.W., Walsh P.N., White D. // J. Phys. Chem. 1961. V. 65. № 8. P. 1400. https://doi.org/10.1021/J100826A029
Vorozhtcov V.A., Stolyarova V.L., Lopatin S.I. et al. // J. Alloys Compd. 2018. V. 735. P. 2348. https://doi.org/10.1016/J.JALLCOM.2017.11.319
Stolyarova V.L., Vorozhtcov V.A., Lopatin S.I., Shugurov S.M. // Russ. J. Gen. Chem. 2020. V. 90. № 5. P. 874. [Столярова В.Л., Ворожцов В.А., Лопатин С.И., Шугуров С.М. // Журн. общ. химии. 2020. Т. 90. № 5. С. 787. https://doi.org/10.31857/S0044460X20050194]https://doi.org/10.1134/S1070363220050199
Hilpert K. // Rapid Commun. Mass Spectrom. 1991. V. 5. № 4. P. 175. https://doi.org/10.1002/rcm.1290050408
Drowart J., Chatillon C., Hastie J., Bonnell D. // Pure Appl. Chem. 2005. V. 77. № 4. P. 683. https://doi.org/10.1351/pac200577040683
Lopatin S.I., Shugurov S.M., Tyurnina Z.G., Tyurnina N.G. // Glass Phys. Chem. 2021. V. 47. № 1. P. 38. [Лопатин С.И., Шугуров С.М., Тюрнина З.Г., Тюрнина Н.Г. // Физика и химия стекла. 2021. Т. 47. № 1. С. 50. https://doi.org/10.31857/S0132665121010078]https://doi.org/10.1134/S1087659621010077
Lopatin S.I. // Glass Phys. Chem. 2022. V. 48. № 2. P. 117. [Лопатин С.И. // Физика и химия стекла. 2022. Т. 48. № 2. С. 163. https://doi.org/10.31857/S0132665122020056]https://doi.org/10.1134/S1087659622020055
Семенов Г.А., Николаев Е.Н., Францева К.Е. Применение масс-спектрометрии в неорганической химии. Л.: Химия. Ленингр. отд-ние, 1976. 151 с.
Paule R.C., Mandel J. // Pure Appl. Chem. 1972. V. 31. № 3. P. 371. https://doi.org/10.1351/pac197231030371
Zeifert P.L. // High Temperature Technology. N.Y.: John Wiley, 1956. P. 485.
Сидоров Л.Н., Акишин П.А. // Докл. АН СССР. 1963. № 151. № 1. С. 136.
Sidorov L.N., Shol’ts V.B. // Int. J. Mass Spectrom. Ion Phys. 1972. V. 8. № 5. P. 437. https://doi.org/10.1016/0020-7381(72)80014-7
Redlich O., Kister A.T. // Ind. Eng. Chem. 1948. V. 40. № 2. P. 345. https://doi.org/10.1021/ie50458a036
Wilson G.M. // J. Am. Chem. Soc. 1964. V. 86. № 2. P. 127. https://doi.org/10.1021/ja01056a002
Orye R. V., Prausnitz J.M. // Ind. Eng. Chem. 1965. V. 57. № 5. P. 18. https://doi.org/10.1021/ie50665a005
Hardy H.K. // Acta Metall. 1953. V. 1. № 2. P. 202. https://doi.org/10.1016/0001-6160(53)90059-5
Hildebrand J.H. // J. Am. Chem. Soc. 1929. V. 51. № 1. P. 66. https://doi.org/10.1021/ja01376a009
Kohler F. // Monatsh. Chem. 1960. V. 91. № 4. P. 738. https://doi.org/10.1007/BF00899814
Vorozhtcov V.A., Kirillova S.A., Shilov A.L. et al. // Mater. Today Commun. 2021. V. 29. P. 102952. https://doi.org/10.1016/j.mtcomm.2021.102952
Darken L.S. // J. Am. Chem. Soc. 1950. V. 72. № 7. P. 2909. https://doi.org/10.1021/ja01163a030
Barker J.A. // J. Chem. Phys. 1952. V. 20. № 10. P. 1526. https://doi.org/10.1063/1.1700209