Electrically conductive nonwoven materials produced by electrospinning of polyaniline and bulk polymers

Мұқаба

Дәйексөз келтіру

Толық мәтін

Ашық рұқсат Ашық рұқсат
Рұқсат жабық Рұқсат берілді
Рұқсат жабық Тек жазылушылар үшін

Аннотация

Electrically conductive micro- and nanofibrous nonwoven materials were obtained by electrospinning of solutions of polyaniline and a number commodity polymers (polyamide-6, polylactic acid, polystyrene, polyethylene oxide). The average fiber diameter is in the range of 0.5–6 μm, while the addition of polyaniline into the spinning solution leads to a decrease in fiber diameter. The composition of the obtained materials was confirmed by IR spectroscopy. It was found that during the electrospinning process the supramolecular structure of polyamide-6 and polylactide changes (from α-phase to γ- and amorphous phases, respectively), and polyaniline does not form crystalline structures. The specific electrical conductivity of the obtained nonwoven fabrics can reach 10−3 S/cm, which allows their application both in tissue engineering and in organic electronics.

Толық мәтін

Рұқсат жабық

Авторлар туралы

S. Malakhov

National Research Center “Kurchatov Institute”

Хат алмасуға жауапты Автор.
Email: s.malakhov@mail.ru
Ресей, Moscow

Yu. Malakhova

National Research Center “Kurchatov Institute”; MIREA – Russian Technological University

Email: s.malakhov@mail.ru

M.V. Lomonosov Moscow State Institute of Fine Chemical Technologies

Ресей, Moscow; Moscow

S. Chvalun

National Research Center “Kurchatov Institute”

Email: s.malakhov@mail.ru
Ресей, Moscow

Әдебиет тізімі

  1. Kenry, Lim C.T. // Prog. Polym. Sci. 2017. V. 70. P. 1. https://doi.org/10.1016/j.progpolymsci.2017.03.002
  2. Wang X.X., Yu G.F., Zhang J. et al. // Prog. Mater. Sci. 2021. V. 115. P. 100704. https://doi.org/10.1016/j.pmatsci.2020.100704
  3. Hwang J., Muth J., Ghosh T. // J. Appl. Polym. Sci. 2007. V. 104. P. 2410. https://doi.org/10.1002/app.25914
  4. Victor F.S., Kugarajah V., Bangaru M., Dharmalingam S. // J. Electrostat. 2022. V. 119. P. 103738. https://doi.org/10.1016/j.elstat.2022.103738
  5. Mazinani S., Ajji A., Dubois C. // J. Polym. Sci. B. Polym. Phys. 2010. V. 48. P. 2052. https://doi.org/10.1002/polb.22085
  6. Yang T., Wu D., Lu L. et al. // Polym. Compos. 2011. V. 32. P. 1280. https://doi.org/10.1002/pc.21149
  7. Naeem F., Prestayko R., Saem S. et al. // Nanotechnology. 2015. V. 26. P. 395301. https://doi.org/10.1088/0957-4484/26/39/395301
  8. Bao Q., Zhang H., Yang J.X. et al. // Adv. Funct. Mater. 2010. V. 20. P. 782. https://doi.org/10.1002/adfm.200901658
  9. Azarniya A., Eslahi N., Mahmoudi N., Simchi A. // Compos. A. Appl. Sci. Manuf. 2016. V. 85. P. 113. https://doi.org/10.1016/j.compositesa.2016.03.011
  10. Li Y., Zhang P., Ouyang Z. et al. // Adv. Funct. Mater. 2016. V. 26. P. 2122. https://doi.org/10.1002/adfm.201504533
  11. Liu Y., Teng H., Hou H., You T. // Biosens. Bioelectron. 2009. V. 24. P. 3329. https://doi.org/10.1016/j.bios.2009.04.032
  12. Zhu H., Du M., Zhang M. et al. // Sensor. Actuat. B. Chem. 2013. V. 185. P. 608. https://doi.org/10.1016/j.snb.2013.05.062
  13. Alegre C., Busacca C., Di Blasi A. et al. // J. Energy Storage. 2019. V. 23. P. 269. https://doi.org/10.1016/j.est.2019.04.001
  14. Jur J.S., Sweet III W.J., Oldham C.J., Parsons G.N. // Adv. Funct. Mater. 2011. V. 21. P. 1993. https://doi.org/10.1002/adfm.201001756
  15. Климова С.А., Аткин В.С., Усачев А.Н. и др. // Хим. волокна. 2017. № 3. С. 66.
  16. Das T.K., Prusty S. // Polym.-Plast. Technol. 2012. V. 51. P. 1487. https://doi.org/10.1080/03602559.2012.710697
  17. Namsheer K., Rout C.S. // RSC Adv. 2021. V. 11. P. 5659. https://doi.org/10.1039/D0RA07800J
  18. Majeed A.H., Mohammed L.A., Hammoodi O.G. et al. // Int. J. Polym. Sci. 2022. V. 2022. P. 9047554. https://doi.org/10.1155/2022/9047554
  19. Zhang Y., Rutledge G.C. // Macromolecules. 2012. V. 45. P. 4238. https://doi.org/10.1021/ma3005982
  20. Das S., Sharma M., Saharia D. et al. // Biomed. Mater. 2017. V. 12. P. 045025. https://doi.org/10.1088/1748-605X/aa7802
  21. Farkhondehnia H., Amani Tehran M., Zamani F. // Fiber. Polym. 2018. V. 19. P. 1813. https://doi.org/10.1007/s12221-018-8265-1
  22. Frontera P., Busacca C., Trocino S. et al. // J. Nanosci. Nanotechnol. 2013. V. 13. P. 4744. https://doi.org/10.1166/jnn.2013.7196
  23. Li C., Chartuprayoon N., Bosze W. et al. // Electroanal. 2014. V. 26. P. 711. https://doi.org/10.1002/elan.201300641
  24. Yao J., Chen Y., Li W. et al. // RSC Adv. 2019. V. 9. P. 5610. https://doi.org/10.1039/C8RA10495F
  25. Liu Y., Cui L., Guan F. et al. // Macromolecules. 2007. V. 40. P. 6283. https://doi.org/10.1021/ma070039p
  26. Малахов С.Н., Чвалун С.Н. // Российские нанотехнологии. 2020. Т. 15. № 4. С. 477. https://doi.org/10.1134/S1992722320040093
  27. Hsieh Y.T., Nozaki S., Kido M. et al. // Polym. J. 2020. V. 52. P. 755. https://doi.org/10.1038/s41428-020-0343-8
  28. Малахов С.Н., Малышкина А.М., Чвалун С.Н. // Журн. прикл. химии. 2022. Т. 95. № 9. С. 1179. https://doi.org/10.31857/S0044461822090109
  29. Deitzel J.M., Kleinmeyer J.D., Hirvonen J.K., Tan N.B. // Polymer. 2001. V. 42. P. 8163. https://doi.org/10.1016/S0032-3861(01)00336-6
  30. Малахова Ю.Н., Малахов С.Н., Камышинский Р.А. и др. // Журн. прикл. химии. 2017. Т. 90. № 9. С. 1252.
  31. Chae D.W., Kim B.C. // Polym. Adv. Technol. 2005. V. 16. P. 846. https://doi.org/10.1002/pat.673
  32. Малахов С.Н., Кузнецов Н.М., Вдовиченко А.Ю. и др. // Хим. волокна. 2023. № 6. С. 56.
  33. Al-Gharram M., Jum'h I., Telfah A., Al-Hussein M. // Colloid. Surf. A. 2021. V. 628. P. 127342. https://doi.org/10.1016/j.colsurfa.2021.127342
  34. Śniechowski M., Borek R., Piwowarczyk K., Łużny W. // Macromol. Theor. Simul. 2015. V. 24. P. 284. https://doi.org/10.1002/mats.201400105
  35. Garrudo F.F.F., Ferreira L.V., Ferraria A.M. et al. // Synthetic Met. 2024. V. 301. P. 117523. https://doi.org/10.1016/j.synthmet.2023.117523
  36. Olvera-Gracia M., Aguilar-Hernandez J.R. // J. Appl. Res. Technol. 2014. V. 12 P. 598. https://doi.org/10.1016/S1665-6423(14)71638-4
  37. Picciani P.H., Medeiros E.S., Pan Z. et al. // J. Appl. Polym. Sci. 2009. V. 112. № 2. P. 744. https://doi.org/10.1002/app.29447
  38. Ucar N., Kizildag N., Onen A. et al. // Fiber. Polym. 2015. V. 16. P. 2223. https://doi.org/10.1007/s12221-015-5426-3
  39. Костина Ю.В., Бондаренко Г.Н., Алентьев А.Ю., Ямпольский Ю.П. // Высокомол. соед. Сер. А. 2006. Т. 48. № 1. С. 41.
  40. Moseti K.O., Yoshioka T., Kameda T., Nakazawa Y. // Molecules. 2019. V. 24. P. 3945. https://doi.org/10.3390/molecules24213945

Қосымша файлдар

Қосымша файлдар
Әрекет
1. JATS XML
Жүктеу

© Russian Academy of Sciences, 2025